WikiLeaks Document Release
http://wikileaks.org/wiki/CRS-RS22707
February 2, 2009
Congressional Research Service
Report RS22707
Mine-Resistant, Ambush-Protected (MRAP) Vehicles:
Background and Issues for Congress
Andrew Feickert, Foreign Affairs, Defense, and Trade Division
August 1, 2008
Abstract. In late 2007, the Department of Defense (DOD) launched a major procurement initiative to
replace most uparmored High Mobility, Multi-Wheeled Vehicles (HMMWVs) in Iraq with Mine-Resistant,
Ambush-Protected (MRAP) vehicles by FY2009. MRAPs have been described as providing significantly more
protection against Improvised Explosive Devices (IEDs) than uparmored HMMWVs. DOD's decision not to
procure MRAP IIs, MRAP logistical and readiness concerns, and MRAP rollover accidents could be potential
policy issues for congressional consideration.
Order Code RS22707
Updated August 1, 2008
Mine-Resistant, Ambush-Protected (MRAP)
Vehicles: Background and Issues
for Congress
Andrew Feickert
Specialist in Military Ground Forces
Foreign Affairs, Defense, and Trade Division
Summary
http://wikileaks.org/wiki/CRS-RS22707
In late 2007, the Department of Defense (DOD) launched a major procurement
initiative to replace most uparmored High Mobility, Multi-Wheeled Vehicles
(HMMWVs) in Iraq with Mine-Resistant, Ambush-Protected (MRAP) vehicles by
FY2009. MRAPs have been described as providing significantly more protection
against Improvised Explosive Devices (IEDs) than uparmored HMMWVs. DOD's
decision not to procure MRAP IIs, MRAP logistical and readiness concerns, and MRAP
rollover accidents could be potential policy issues for congressional consideration. This
report will be updated.
Background
MRAPs are a family of vehicles produced by a variety of domestic and international
companies that generally incorporate a "V"-shaped hull and armor plating designed to
provide protection against mines and improvised explosive devices (IEDs). DOD is
procuring three types of MRAPs.1 These include Category I vehicles, capable of carrying
up to 7 personnel and intended for urban operations; Category II vehicles, capable of
carrying up to 11 personnel and intended for a variety of missions such as supporting
security, convoy escort, troop or cargo transport, medical, explosive ordnance disposal,
or combat engineer operations; and Category III vehicles, intended to be used primarily
to clear mines and IEDs, which are capable of carrying up to 13 personnel. The Army and
Marines first employed MRAPs in limited numbers in Iraq and Afghanistan in 2003,
primarily for route clearance and explosive ordnance disposal (EOD) operations. These
route clearance MRAPs quickly gained a reputation for providing superior protection for
their crews, and some suggested that MRAPs might be a better alternative for transporting
troops in combat than uparmored HMMWVs.
1
U.S. Government Accountability Office (GAO) Report, Subject: Rapid Acquisition of Mine
Resistant Ambush Protected Vehicles, July 15, 2008.
CRS-2
DOD Accelerates the MRAP Program. Secretary of Defense Robert Gates
directed that "the MRAP program should be considered the highest priority Department
of Defense acquisition program."2 Secretary Gates established the MRAP Task Force to
speed production and fielding of MRAPs and assigned the Marines to manage all MRAP
procurement for DOD. The MRAP program was designated a "DX" program, giving it
priority for resources.3
DOD's MRAP Requirement.4 DOD has approved the following MRAP
acquisitions quantities by service and for other uses: Army, 12,000; Marine Corps, 2,225;
Navy, 544; Air Force, 558; U.S. Special Operations Command (USSOCOM), 378; and
ballistic testing, 133, for a total of 15,858 vehicles of all categories.
MRAP Survivability.5 DOD officials have stated that the casualty rate for MRAPs
is 6%, making it "the most survivable vehicle we have in our arsenal by a multitude." By
comparison, the M-1 Abrams main battle tank was said to have a casualty rate of 15%,
and the uparmored HMMWV, a 22% casualty rate. DOD noted that in more than 150
attacks on MRAPs, seven MRAP occupants had been killed and an undisclosed number
had been wounded.
http://wikileaks.org/wiki/CRS-RS22707
MRAPs Deployed to Iraq and Afghanistan
On July 3, 2008, DOD announced that the 10,000th MRAP had rolled off the
assembly line and into government hands.6 The following sections address MRAPs
deployed to Iraq and Afghanistan.
MRAPs in Iraq. According to one report, as of June 25, 2008, 5,501 MRAPs had
been fielded in Iraq and many hundreds more were in the MRAP "pipeline" bound for
Iraq.7 As of that date, 600 additional MRAPs were deprocessing in Iraq, with 107 of
those ready for issue. An additional 780 MRAPs were en route by ship to the
USCENTCOM area of operations (AOR) -- a 23-day trip.
2
Memorandum from Secretary of Defense Robert Gates, "MRAP Acquisition," May 2, 2007.
3
Jason Sherman, "Gates Establishes MRAP Task Force to Speed Up Production, Fielding,"
InsideDefense.com, June 4, 2007, and Emelie Rutherford, "Gates Approves DX Rating for
MRAP," InsideDefense.com, June 4, 2007.
4
U.S. Government Accountability Office (GAO) Report, Subject: Rapid Acquisition of Mine
Resistant Ambush Protected Vehicles, July 15, 2008.
5
Information in this section is taken from DOD Press Transcripts, "DOD News Briefing with
Geoff Morrell," May 15, 2008.
6
DOD Statement on 10,000th MRAP Delivery, No. 565-08, July 3, 2008.
7
Information in this section is from Marjorie Censer, "More Than 10,000 MRAP Vehicles
Accepted by Pentagon as of Last Week," InsideDefense.com, July 7, 2008.
CRS-3
MRAPs in Afghanistan.8 According to Pentagon officials, there are currently
about 800 MRAPs in Afghanistan. On July 17, 2008, the Pentagon announced a contract
award for another 813 MRAPs and suggested that the entire order would be sent to
Afghanistan. These additional MRAPs will likely be the 9-ton RG-31 Category I MRAPs,
the smallest version, which is said to be better suited for Afghanistan's unimproved roads
and rugged terrain. About 600 of the almost 800 MRAPs currently in Afghanistan are RG-
31s. DOD is increasing the numbers of MRAPs being sent to Afghanistan due to
increasing attacks by insurgents, requests from commanders in theater, and possibly in
anticipation of the introduction of additional U.S. combat forces.
MRAP Contract Activity
Most Recent MRAP Order.9 As previously noted, the Pentagon placed a $612
million order with General Dynamics and BAE Systems for MRAPs on July 17, 2008.
This order includes 773 MRAPs with engineering change proposal (ECP) improvements
to better protect against explosively-formed penetrators (EFPs), a type of stand-off
improvised explosive device that employs a shaped charge against the sides of vehicles.
An additional 40 MRAPs under this contract are for U.S. Special Operations Command.
http://wikileaks.org/wiki/CRS-RS22707
DOD plans to procure an additional 787 MRAPs as part of its final order of 1,600
vehicles required to complete DOD's total MRAP requirement.
DOD Decides Not to Procure MRAP IIs.10 On July 31, 2007, the Marines
issued a request for proposal for the MRAP II Enhanced Vehicle Competition. The
MRAP II was intended to better address the threat of EFPs.11 In December 2007, MRAP
program officials announced that only two companies -- BAE Systems and a team led
by Ideal Innovations,12 a consultant based in Alexandria, Virginia -- were selected to
provide six test vehicles each to be evaluated by DOD.13 In June 2008, MRAP program
officials were said to be unsure whether MRAP II testing would be completed in time so
8
Jim Garamone, "Officials Seek More MRAPs for Afghanistan," American Forces Press
Services, July 16, 2008; Associated Press, "GIs Get More Bomb Protection in Afghanistan,"
MSNBC.com, July 17, 2008; Marjorie Censer, "Pentagon Orders Nearly 800 More MRAPs for
The Army; Trucks Likely Headed to Afghanistan," InsideDefense.com, July 17, 2008; Kris
Osborn, "Lighter MRAPS in the Works," Army Times, July 28, 2008.
9
Information in this section is from Emelie Rutherford, "Pentagon Orders 813 Mine-Resistant
Vehicles from General Dynamics, BAE Systems," Defense Daily, July 18, 2008.
10
Emelie Rutherford and Jason Sherman, "Solicitation Expected to be Released this Week for
MRAP II Competition," InsideDefense.com, July 30, 2007, and Jason Sherman, "Pentagon Eyes
More than a Dozen New Potential Vendors for MRAP II," InsideDefense.com, August 1, 2007.
11
Tom Vanden Brook, "MRAPs May Need Extra Armor Face EFPs," USA Today, May 31, 2007
and "Add-On Armor Too Heavy for MRAPs," USA Today, July 17, 2007.
12
The Ideal Innovations Team consists of Oskosh Truck from Oskosh, WI and Ceradyne from
Costa Mesa, CA.
13
Emelie Rutherford, "Two Companies Pass Muster in Testing for Next-Gen MRAP Vehicles,"
Inside the Navy, December 24, 2007.
CRS-4
that MRAP IIs could be included in the July 2008 MRAP order.14 Despite the possibility
of not being included in the 1,600-vehicle order for the Army, MRAP program officials
stated that the MRAP II program would continue as currently planned.15 In July 2008,
DOD officials decided not to purchase the 30-ton MRAP IIs -- after spending more than
$25 million and one year to develop them -- supposedly because of mobility and safety
issues.16
Lighter MRAPs to Be Procured?17 DOD's final order of 787 MRAPs may
include a lighter and shorter MRAP version to address rollover accidents and to improve
mobility. The Pentagon is said to be studying engineering change proposals that will
increase the MRAP's stability while preserving survivability. These lighter MRAPs
would carry fewer passengers and crews, but a shorter and lighter MRAP could make
MRAPs a little easier for drivers to handle and increase the vehicle's ability to negotiate
different types of terrain. Commanders in the field have reported that current MRAP
versions have difficulties operating in urban or dense environments and on unimproved
roads and in cross country operations.
MRAP Funding
http://wikileaks.org/wiki/CRS-RS22707
According to DOD, there was no procurement or development funding requested for
FY2009, as the MRAP acquisition objective would be achieved with FY2008 funds.18
On May 22, 2008, the Senate approved an amended version of H.R. 2642, Supplemental
Appropriation Act for 2008, appropriating $1.7 billion for MRAPs.19 In addition to
MRAP procurement, these funds included funding for the ballistic testing, sustainment,
and transport of MRAPs, and the committee also directed the Secretary of Defense to
include future MRAP funding requests in the President's Budget Request starting in
FY2010.20 On July 3, 2008, the Pentagon Comptroller notified Congress that DOD
intended to transfer $1.737 billion out of its FY2008 MRAP Vehicle Fund to buy 1,576
MRAPs for the Army and 34 for U.S. Special Operations Command.21
14
Daniel Wasserbly, "MRAP II Could Miss Upcoming July Contract Award, Young Says,"
InsideDefense.com, June 3, 2008 and Emelie Rutherford, "DOD Eyes Stretching Out Coming
MRAP Order, Unclear if MRAP II Will Be Part," Defense Daily, June 4, 2008.
15
Ibid.
16
Kris Osborn, "Lighter MRAPS in the Works," Army Times, July 28, 2008.
17
Ibid.
18
DOD FY2009 Budget Request Summary Justification, February 4, 2008, p. 183.
19
CRS Report RL34451, Second FY 2008 Supplemental Appropriations for Military Operations,
International Affairs and Other Purposes.
20
John Liang, "Senate Appropriators Approve $1.7 Billion in MRAP Funding, $3.6 Billion for
C-17s," InsideDefence.com, May 15, 2008.
21
Emelie Rutherford, "Pentagon Orders 813 Mine-Resistant Vehicles from General Dynamics,
BAE Systems," Defense Daily, July 18, 2008.
CRS-5
MRAP Operational Concerns
MRAP Logistical and Readiness Issues. At the program level, GAO notes
that "operating, maintaining, and sustaining a fleet of 15,000 fielded vehicles by at least
five different vendors could present significant challenges."22 In order to address this
concern, the Army is trying to "pure fleet" its MRAPs in Afghanistan by acquiring the
RG-31 variant from a single vendor. Because Afghanistan does not have the MRAP
logistical support infrastructure that is available to U.S. forces in Iraq, this is considered
a prudent strategy by many. Another concern is that, at present, much of the MRAP
maintenance is being performed by contractors as DOD adjusts its long-term maintenance
strategy so that maintenance will be performed by military personnel. During this
transition period, it is possible that there might be contractor maintenance shortages in
Iraq and Afghanistan.
It was recently reported that one in five MRAPs in Iraq were out of service (which
correlates to an 80% readiness rate) primarily due to a lack of repair parts.23 The Pentagon
has disputed this claim and maintains that its operational readiness rate for MRAPs in Iraq
is almost 92%.24 Sufficient repair parts may also be a readiness concern in Iraq and
http://wikileaks.org/wiki/CRS-RS22707
Afghanistan, as DOD admits it is trying to "catch up" in terms of MRAP repair parts.25
In the past, shortages of heavy duty transmissions, engines, axles, and tires have been
cited as MRAP readiness issues.
MRAP Rollovers. The deaths of three U.S. Army Special Forces soldiers in
Afghanistan on June 29, 2008, when their RG-31 MRAP rolled over into a river has
renewed concerns about the high risk of MRAP rollover.26 More than half of accidents
involving MRAPs since November 2007 have been rollovers, and nearly 75% of these
rollovers occurred in rural areas. Pentagon officials maintain that rollover risks are
greatest in Afghanistan, where terrain makes movement more difficult, and it was also
noted roads and road shoulders in the region do not meet U.S. standards and can collapse
under the weight of MRAPs -- particularly when the road is above grade. The MRAP's
high center of gravity, weight, and height further compound the rollover issue. There have
also been reports that the MRAP's height (including antennae) have resulted in it striking
power lines, which could result in electrocutions.
22
U.S. Government Accountability Office (GAO) Report, Subject: Rapid Acquisition of Mine
Resistant Ambush Protected Vehicles, July 15, 2008.
23
Suzanne Malveaux, "One Out of Five MRAPs in Iraq is Out of Commission," CNN, July 8,
2008.
24
Jason Sherman, "MRAP Operational Readiness Rates Exceed 90 Percent Goal; Nine Trucks
Destroyed," InsideDefense.com, July 11, 2008.
25
Ibid.
26
Information in this section is from Bryan Mitchell and Andrew Scutro, "MRAP Dangers,"
Army Times, July 14, 2008, pp. 8-9.
CRS-6
Potential Issues for Congress
DOD's Decision to Not Acquire MRAP IIs. There are potential issues
associated with DOD's decision to not acquire MRAP IIs. Does this decision end any
further development of MRAP IIs or is the program "on hold"? DOD was said to have
spent more than $25 million on the MRAP II before its July 2008 decision -- did
anything result from the expenditure of this $25 million that will benefit the MRAP
program as a whole, or is the money essentially lost? Will engineer change proposals for
current production models of MRAPs that address EFPs be as effective as the proposed
MRAP II designs? Are there other potential or emerging threats that might be better
addressed by MRAP II designs?
MRAP Logistics and Readiness. GAO has expressed concern that "operating,
maintaining, and sustaining a fleet of 15,000 fielded vehicles by at least five different
vendors could present significant challenges."27 While DOD contends that there is a
degree of commonality between MRAPs from various vendors, there are likely
considerable logistics and maintenance issues resulting from the mixed MRAP fleet.
These issues could have significant readiness and cost issues that Congress might wish
http://wikileaks.org/wiki/CRS-RS22707
to review with DOD. While DOD's long-term goal is to transition from contractor to
military maintenance for MRAPs, contractors are presently responsible for the majority
of MRAP maintenance activities. Are there sufficient contractors in Iraq and Afghanistan
to support the ever-growing MRAP fleets? Is the quality and availability of contractor
MRAP maintenance comparable to military maintenance and is this a significant factor
in MRAP readiness? DOD is currently "catching up" in terms of acquiring and
stockpiling MRAP repair parts. Is this shortage a function of funding, the ability of the
respective MRAP manufacturers to produce sufficient stocks of repair parts, of
programmatic priorities, or a combination of factors?
MRAP Rollovers.28 Primarily in response to MRAP rollovers, DOD is exploring
design modifications and modifying driver training. Another possible solution might be
to impose operational restrictions on MRAPs, which could further limit their tactical
utility. DOD is putting its emphasis on improving driver training. It is possible that the
MRAP rollover problem may be predominately a function of basic MRAP design and the
current operational environment, and less a function of driver training and skill. If
modifying MRAP design proves to be a significant mitigating factor in MRAP rollovers,
is it possible to modify the thousands of deployed MRAPs and those already
manufactured and in the MRAP pipeline? If these MRAPs can be modified, what are the
associated funding issues ? If these MRAPs can not be appreciably modified, this could
result in two categories of MRAPs -- those prone to rollovers and newer, safer models.
This situation could result operational limitations for the various models and perceived
inequities for those soldiers that operate and are transported in the more rollover-prone
MRAPs.
27
U.S. Government Accountability Office (GAO) Report, Subject: Rapid Acquisition of Mine
Resistant Ambush Protected Vehicles, July 15, 2008.
28
Donna Miles, "Officials Strive to Reduce Preventable MRAP Accidents," American Forces
Press Service, July 28, 2008.